Tools and materials:
* New transmission solenoids kit
* Transmission fluid
*Transmission funnel
* Needle nose pliers
*Cleaning cloth
Replacement procedure:
1. Safety first
* Make sure the vehicle is parked on a level surface and the parking brake is set.
* Allow the engine to cool to avoid burns.
2. Drain the transmission fluid
* Locate the drain plug under the transmission.
* Place a container with a volume of at least 4 liters under it.
* Unscrew the drain plug and drain all the liquid into a container.
3. Remove the transmission pan
*Locate the bolts or screws securing the transmission pan to the transmission housing.
* Remove all bolts or screws and carefully remove the pan.
4. Inspect the tray and magnets
* Inspect the tray and magnets for metal shavings or other signs of wear.
* Clean the pan of any dirt or debris.
5. Replace solenoids
*Locate the solenoids located on the transmission housing.
*Using needle nose pliers, disconnect the electrical connectors from the solenoids.
* Unscrew the bolts securing the solenoids and remove them from the gearbox housing.
* Reinstall the new solenoids and tighten the bolts.
* Connect the electrical connectors to the solenoids.
6. Install the transmission pan gasket
* Clean the surfaces of the gearbox housing and pan where the gasket will be installed.
* Apply a thin layer of sealant to one side of the new gasket.
* Install the gasket onto the transmission housing and tighten the bolts or screws.
7. Install the transmission pan
* Lift the transmission pan and align it with the transmission housing.
* Tighten the bolts or screws to secure the tray.
8. Fill with transmission fluid
*Insert a funnel into the transmission dipstick hole.
* Pour transmission fluid into the transmission until it reaches the “Full” mark on the dipstick.
9. Check fluid level
* Start the engine and let it idle for a few minutes.
* Shift the gear selector to all positions and return to Park.
* Check the fluid level on the transmission dipstick. It should be between the “Min.” marks. and “Max.”
10. Clean up spills
* Clean up any transmission fluid spills around the transmission or under the vehicle.
11. Drive a car
* Drive the car and let it travel for several kilometers. This will allow the transmission fluid to be evenly distributed throughout the system.
* Check the fluid level again and add fluid if necessary.